Quantcast
  

Sunday, April 20, 2014         

 Print   Email   Comment | View 3 Comments   Most Popular   Save   Post   Retweet

Feds to probe Ford cars and SUVs for stalling

By Tom Krisher

AP Auto Writer

POSTED:
LAST UPDATED: 05:25 a.m. HST, Feb 25, 2013


DETROIT » The National Highway Traffic Safety Administration says it will investigate problems with stalling or surging engines in nearly 725,000 Ford cars and SUVs.

The probe affects Ford Escape and Mercury Mariner SUVs and Ford Fusion and Mercury Milan sedans from the 2009 through 2011 model years.

The vehicles can unexpectedly go into "limp home mode" at reduced power, the agency said in documents posted today on its website. NHTSA and Ford have received almost 1,500 complaints about the problem. There were three crashes and one injury.

NHTSA began looking into the cars and SUVs after getting a request from the North Carolina Consumers Council last year. Nonprofit safety groups and consumers can petition the agency to investigate vehicle problems.

The cars and SUVs haven't been recalled, but the investigation could lead to a recall.

The Fusion and Milan are nearly identical cars with the same engines, as are the Escape and Mariner. Ford scrapped the Mercury brand in 2010.

The North Carolina organization said it received two complaints about 2009 Escapes that had been diagnosed with throttles either stuck open or closed. The group said that owners reported repeated stalling and surging.

Ford told NHTSA that vehicles made from June 22, 2009, to Oct. 15, 2009, may have faulty printed circuit boards that control the throttles. Ford and its throttle body supplier, Delphi Corp., changed the circuit board manufacturing process after Oct. 15, 2009. That resolved the problem, NHTSA said in documents posted today on its website.

NHTSA said it analyzed 123 complaints about the cars or SUVs going into what's known as limp mode, in which vehicle speed was limited to 20 mph or 900 engine revolutions per minute. Drivers may interpret the limp mode as stalling, even though the engines still move the vehicles, the agency said. Vehicles usually go into limp mode when computers detect an engine problem. This allows drivers to get to a safe place while protecting the engine from damage.

Power surges appear to happen when the engine revolutions fluctuate to prevent stalling during limp mode, the agency said.

But even though Ford said the throttle problem with the Escape was resolved with the manufacturing change, NHTSA still decided to investigate vehicles from the 2010 and 2011 model years. The agency says it received 59 complaints of engine stalling in 2010 and 2011 Fusions. Eighty percent of the complaints were received starting in March of 2012, showing an increasing trend, the agency said.

In addition, Ford has received 27,505 warranty claims in which the throttle bodies were repaired or replaced, NHTSA said.







 Print   Email   Comment | View 3 Comments   Most Popular   Save   Post   Retweet

COMMENTS
(3)
You must be subscribed to participate in discussions
By participating in online discussions you acknowledge that you have agreed to the TERMS OF SERVICE. An insightful discussion of ideas and viewpoints is encouraged, but comments must be civil and in good taste, with no personal attacks. Because only subscribers are allowed to comment, we have your personal information and are able to contact you. If your comments are inappropriate, you may receive a warning, and if you persist with such comments you may be banned from posting. To report comments that you believe do not follow our guidelines, email commentfeedback@staradvertiser.com.
Leave a comment

Please login to leave a comment.
manakuke wrote:
Very interesting.
on February 25,2013 | 04:28AM
lokela wrote:
I have a 2010 Escape and it did stall out. Ford replaced the throttle body. So far so good. But it was very dangerous as I stalled out more then once. A recall is needed for safety purposes.
on February 25,2013 | 05:11AM
hikine wrote:
I used to love Ford but when I bought a 2000 Focus and was recalled multiple times. I also owned a Pontiac and it too was recalled multiple times. I swore to not to buy any more domestic cars so I bought a Hyundai, best car I've owned so far. Japanese cars also have multiple recalls.
on February 25,2013 | 10:32AM
IN OTHER NEWS
Breaking News